1. Prodott Aktarview
The Rittal 3383500 Top Therm Roof Mounted Air Conditioner is designed for efficient cooling of industrial enclosures. Featuring a comfort controller, this unit provides reliable temperature management for sensitive equipment. It is built for durability and ease of installation, offering a robust solution for thermal management.
Karatteristiċi ewlenin:
- Fully wired ready for connection, including drilling templates and assembly hardware.
- Equipped with a nano-coated condenser coil and integrated condensate evaporator.
- Operates on 230 Volt power supply with 50/60 Hertz operating frequency.
- Compact dimensions: 23-1/2" width x 16-21/64" height x 18-11/16" depth.
- Ratings: IP 54, NEMA 12.
- Cooling Capacity: 3688 BTU at 60Hz.
Figura 1: Quddiem view of the Rittal 3383500 Top Therm Roof Mounted Air Conditioner, showcasing its light grey finish and front grille.
2. Setup u Installazzjoni
Before beginning installation, ensure the power supply is disconnected. This unit is designed for roof mounting on industrial enclosures.
2.1 Verifiki ta' qabel l-Installazzjoni:
- Verify the enclosure roof can support the unit's weight (approximately 92.5 lbs).
- Confirm power supply matches unit requirements (230V, 50/60Hz).
- Ensure adequate clearance around the unit for proper airflow and maintenance.
2.2 Istruzzjonijiet tal-Immuntar:
- Use the provided drilling templates to mark and cut the necessary openings on the enclosure roof.
- Carefully position the air conditioner unit over the openings.
- Secure the unit using the supplied assembly hardware. Ensure all fasteners are tightened to prevent vibration and maintain the IP/NEMA rating.
2.3 Konnessjoni Elettrika:
- The unit is fully wired ready for connection. Connect the power supply to the plug-in terminal strip.
- Aċċerta ruħek li jkun hemm ertjar xieraq skont il-kodiċijiet elettriċi lokali.
- Recommended pre-fuse: T 10.0 A.
Figure 2: Dimensional drawing of the Rittal 3383500 unit, showing its width (23.5"), height (16.33"), and depth (18.69").
3. Istruzzjonijiet Operattivi
The Rittal 3383500 features a comfort controller for easy temperature management.
3.1 L-Inizjali Tixgħel:
- After installation and electrical connection, restore power to the unit.
- The comfort controller display will illuminate.
3.2 Setting Temperature:
- The factory setting for the comfort controller is 95°F (35°C).
- The temperature setting range is 68°F to 131°F (20°C to 55°C).
- Refer to the comfort controller's specific manual (if provided separately) for detailed instructions on adjusting the setpoint. Generally, buttons on the controller allow for increasing jew tnaqqisasing the desired temperature.
3.3 Modi ta' Operazzjoni:
The unit operates automatically to maintain the set temperature within the enclosure. It will cycle on and off as needed to achieve optimal cooling.
4. Manutenzjoni
Regular maintenance ensures optimal performance and extends the lifespan of your Rittal air conditioner. Always disconnect power before performing any maintenance.
4.1 Filter Cleaning/Replacement:
- Inspect air filters regularly (e.g., monthly or quarterly, depending on environment).
- Clean filters using compressed air or mild detergent and water. Ensure they are completely dry before reinstallation.
- Replace filters if they are damaged or cannot be adequately cleaned.
4.2 Condenser Coil Cleaning:
- The unit features a nano-coated condenser coil, which helps reduce dirt buildup. However, periodic inspection and cleaning are still recommended.
- Gently clean the condenser coil fins with a soft brush or vacuum cleaner to remove dust and debris. Avoid bending the fins.
4.3 Condensate Evaporator:
- The integrated condensate evaporator manages condensation. Periodically check for any blockages or excessive water accumulation.
4.4 General Inspection:
- Check all electrical connections for tightness and signs of wear.
- Inspect the unit for any physical damage or corrosion.
- Ensure proper sealing between the unit and the enclosure to maintain environmental ratings.
5 Issolvi l-problemi
This section provides solutions to common issues. For problems not listed here, contact Rittal customer support.
| Problema | Kawża Possibbli | Soluzzjoni |
|---|---|---|
| L-unità ma tixgħelx. | No power supply; Blown fuse/circuit breaker; Loose electrical connection. | Check power source; Inspect and replace fuse/reset breaker; Verify all connections are secure. |
| Unit runs but does not cool effectively. | Dirty air filters; Blocked condenser coil; Incorrect temperature setting; Refrigerant leak (less common). | Clean or replace air filters; Clean condenser coil; Adjust temperature setting; Contact qualified technician for refrigerant issues. |
| Storbju mhux tas-soltu waqt it-tħaddim. | Loose components; Fan obstruction; Motor issue. | Inspect for loose parts and tighten; Clear any obstructions from fans; If noise persists, contact support. |
| Ilma inixxi mill-unità. | Blocked condensate drain/evaporator. | Inspect and clear any blockages in the condensate system. |
6. Speċifikazzjonijiet
| Parametru | Valur |
|---|---|
| Numru tal-Mudell | 3383500 |
| Brand | Rittal |
| Dimensjonijiet (W x H x D) | 23-1/2" x 16-21/64" x 18-11/16" (59.7 cm x 41.5 cm x 47.5 cm) |
| Piż | 92.5 Lira (42 kg) |
| Voltage | 230 V |
| Frekwenza | 50/60 Hz |
| Kurrent Rated | 4.3 A (50Hz) / 4.5 A (60Hz) |
| Kurrent tal-Bidu | 15.5 A |
| Fjus minn qabel | T 10.0 A |
| Cooling Capacity (L35 L35) | 1000 W (3415 BTU) / 1080 W (3688 BTU) |
| Power Consumption (L35 L35) | 550 W (50Hz) / 650 W (60Hz) |
| Refriġerant | R134a, 17.6 oz |
| Firxa tat-Temperatura | 68°F sa 131°F (20°C sa 55°C) |
| Protection Rating (External) | IP 34 (NEMA 2) |
| Protection Rating (Internal) | IP 54 (NEMA 12) |
| Air Displacement (External) | 1036 cfm |
| Air Displacement (Internal) | 259 cfm |
7. Garanzija u Appoġġ
For specific warranty information regarding your Rittal 3383500 air conditioner, please refer to the documentation provided with your purchase or contact Rittal directly. Rittal products typically come with a manufacturer's warranty covering defects in materials and workmanship.
Appoġġ għall-Klijent:
If you require technical assistance, have questions about operation, or need to arrange service, please contact Rittal customer support. You can often find contact information on the Rittal official webis-sit jew permezz tad-distributur tal-prodott tiegħek.
Għal mistoqsijiet ġenerali, tista' żżur il- Rittal Store on Amazon.
